Honda CR-V 2002 2.0i Executive Automatic
Honda CR-V 2002 2.0 petrol description
Crossover / SUV Honda CR-V 2002 2.0i Executive Automatic has been produced from January, 2004 to November, 2004. It has four-cylinder petrol engine with displacement of 2.0 litres, which produces power of 150 horsepower on 6500 rpm and torque 190 Nm (Newton metres) on 4000 revolutions per minute.
This 4-cylinder 16-valve engine camshaft is driven by chain (What is an engine chain and belt? ). Engine has fuel injection system, this is an atmospheric engine (without turbine). Engine versions compliant with Euro 3 and Euro 4 emission standards available. Engine lifespan (mileage before major repairs or overhaul) can last from 270 up to 450 thousand kilometres. Remember that engine life depends on regular maintenance and the quality of the materials used (oils, fuels, etc.).
More engine specs
In 2001, Honda introduced the K-series engine lineup, featuring an aluminum block with an open-deck design and cast-iron cylinder liners. It utilizes a port fuel injection system, a 16-valve aluminum cylinder head without ...
This Honda CR-V 2.0 engine oil type is 5W-30 and oil capacity is 4.2 litres.
Honda CR-V 2002 2.0i Executive Automatic has AWD (all wheel drive) (power is automatically distributed between the wheel axles) and automatic gearbox with 4 gears. Car has Honda`s real-time four-wheel drive system, which sends torque to the front wheels under normal conditions. Multi-plate clutch transfers torque to rear axle when wheel slip is detected (pressure is applied to clutch by dual pump system). To allow ABS to work smoothly, the clutch is also disengaged during braking.
Honda CR-V 2002 2.0i Executive Automatic accelerates to speed 100 kilometres per hour in 12 seconds. The maximum speed of this car is 167 km/h.
Honda CR-V 2002 2.0i Executive Automatic fuel consumption is 9.3 litres per 100km in combined city/highway mode (10.8 km/l) - this is one of most fuel efficient Honda CR-V 2002 - 2004 versions. Fuel tank capacity is 58 litres or 15.32 gallons, which gives a mileage up to 620 kilometers without refueling in urban cycle.
According to user reviews, this Honda real everyday fuel consumption is 11 litres per 100 km, which is 18% more than the manufacturer's stated. More - Real Honda CR-V fuel consumption.
Honda CR-V safety
During safety testing Honda CR-V has obtained 4 stars from five, which means good safety level.
Adults (driver and passenger) safety of Honda CR-V is evaluated with four stars, and for pedestrian protection Honda CR-V got three stars.
- Honda CR-V 2002 2.0i MT 4x4 is more dynamic - it reaches 100 km/h 2 seconds faster (in 10 seconds), moreover, it is more economic with manufacturer's fuel consumption is lower by 0.2 litres per 100 km or 2 % - 9.1 litres per 100 km, whereas users reported real fuel consumption is lower by 1.5 litres per 100 km or 14 % - 9.5 litres per 100 km
- Honda CR-V 2004 2.0i Executive MT 4x4 is more dynamic - it reaches 100 km/h 2 seconds faster (in 10 seconds), moreover, it is more economic with manufacturer's fuel consumption is lower by 0.2 litres per 100 km or 2 % - 9.1 litres per 100 km, whereas users reported real fuel consumption is lower by 1.3 litres per 100 km or 12 % - 9.7 litres per 100 km
Honda CR-V 2002 2.0i Executive Automatic technical data
| Model: | Honda CR-V 2.0i Executive Automatic | ||
|---|---|---|---|
| Body style: | Crossover / SUV | ||
| Production period: | 2004. January ... 2004. November | ||
| Engine: | 1998 cm3 Petrol, 4 cylinders | CO2 emissions: | 221 g/km |
| Power: | 150 HP ON 6500 RPM | Torque: | 190 NM ON 4000 RPM |
| Gearbox: | Automatic gearbox (4 gears) | Drive type: | All wheel drive (AWD, 4x4) |
| Top speed: | 167 km/h | Acceleration 0-100 km/h: | 12.0 seconds |
| Fuel consumption (l/100km): | 9.3 (combined) | ||
| Real fuel consumption: | 11 l/100km (21.4 MPG) by user reviews from various sources | ||
| Fuel tank capacity: | 58 litres (15.3 gallons) | ||
| Car dimensions: | 4.58m (length) 1.78m (width) 1.71m (height) | ||
| Turning diameter: | 10.4 meters | ||
| Seats: | 5 seats | ||
| Trunk capacity: | 527 litres | ||
| Trunk max capacity: | 952 litres (with rear seats folded down) | ||
Honda CR-V 2002 2.0i Executive Automatic engine K20A1, K20A3, K20A4, K20A6
Engine reliability and common problems:
In 2001, Honda introduced the K-series engine lineup, featuring an aluminum block with an open-deck design and cast-iron cylinder liners. It utilizes a port fuel injection system, a 16-valve aluminum cylinder head without hydraulic lifters, individual ignition coils, a VTC cam phaser on the intake, and a timing chain. Standard versions were equipped with a plastic intake manifold with variable geometry and VTEC on the intake side, while performance variants featured an aluminum manifold and VTEC on both camshafts.One of the known weaknesses of this engine family is the premature wear of the exhaust camshaft lobes, primarily affecting non-performance models without VTEC on the exhaust side. To prevent excessive wear, it is crucial to use the recommended oil viscosity and check valve clearances every 40,000 km.
The engine is highly sensitive to maintenance intervals, as dirty oil clogs the fine-mesh filters inside the VTC cam phaser and i-VTEC control valve. By 200,000 km, phase misalignment may occur due to chain elongation or wear in the VTC system.
Oil consumption is another issue. Like many aluminum engines with an open-deck design, it is prone to overheating, and its thin piston rings often become stuck. Low oil levels can lead to spun bearings, making frequent oil checks essential.
The timing chain on the K20A engine is known to stretch, especially around 200,000 km. While a stretched chain does not always produce noise, it can be diagnosed by checking the hydraulic tensioner plunger. Another method is to compare the alignment of timing marks on the cam gears and crankshaft pulley.
Other common complaints include jamming of the variable-length intake manifold system, oil leaks from the front crankshaft seal and i-VTEC control valve, and unstable idle caused by a dirty throttle body or idle air control valve.
Overall, this engine can last around 270,000 to 450,000 km if properly maintained, using the correct quality oil and fuel, and carrying out regular checks and maintenance.
| Engine displacement | 1998 cm3 |
|---|---|
| Number of cylinders | 4 |
| Bore (cylinder diameter) | 86 mm |
| Stroke length (piston move) | 86 mm |
| Compression ratio | 9.7 : 1 |
| Camshaft drive | Timing chain Chain motors are considered more reliable, chain replacement usually is required less often than a timing belt, but they are often louder and vibrate more. More service info |
| Timing chain change interval | 200,000 km (recommended) Sometimes manufacturers do not specify timing chain replacement intervals and design chains for engine life. However, once the recommended change interval has been reached, it is recommended to periodically check the condition of the chain and to change the chain if excessive stretching is detected or if unusual noises from the engine or other symptoms occur. |
| Fuel system | Injection |
| Honda CR-V 2002 2.0i Executive Automatic oil type | 5W-30 |
| Oil capacity | 4.2 litres (4.4 quarts) More service info |
| Power | 150 - 160 HP ON 6500 RPM |
| Torque | 180 - 190 NM ON 4000 RPM |
| Start of production (year) | 2001 |
| Duration of production | 10 years |
| Engine also used on | Honda Civic Honda Accord Honda FR-V Honda Stream |
Generally, the use of an engine in several models and its long production run is an indication of the quality of the engine and the success of its design. |
Most often compared to
All Honda CR-V crossover [2002 - 2004] modifications
| Modification | Engine | Power | Consumption | Gearbox |
|---|---|---|---|---|
|
Honda CR-V 2002 2.0i 4x4
Mar 2002 — Nov 2004 Most dynamic version - 100 km/h in 10 seconds |
2.0 Petrol | 150 HP | 9.1 l/100km | Manual (5) |
|
Honda CR-V 2004 2.0i Executive 4x4
Jan 2004 — Nov 2004 Most dynamic version - 100 km/h in 10 seconds |
2.0 Petrol | 150 HP | 9.1 l/100km | Manual (5) |
| Honda CR-V 2002 2.0i Automatic 4x4 Mar 2002 — Nov 2004 | 2.0 Petrol | 150 HP | 9.3 l/100km | Automatic (4) |
| Honda CR-V 2004 2.0i Executive Automatic 4x4 Jan 2004 — Nov 2004 | 2.0 Petrol | 150 HP | 9.3 l/100km | Automatic (4) |
|
Honda CR-V 2002 2.4 i 16V LX 4x4
Most powerfull version (162 HP) |
2.4 Petrol | 162 HP | 10.1 l/100km | Manual (5) |