Volvo S80 2006 D5 AWD
Volvo S80 2006 2.4 diesel description
Sedan Volvo S80 2006 D5 AWD has been produced from May, 2007 to May, 2008. It has five-cylinder diesel engine with displacement of 2.4 litres, which produces power of 185 horsepower on 4000 rpm and torque 400 Nm (Newton metres) on 2000 revolutions per minute.
This 5-cylinder 20-valve engine camshaft is driven by belt (What is an engine chain and belt? ). Engine has Common Rail fuel system and VGT turbine. The engine meets the Euro 4 emissions standard. Approximate engine life expectancy (mileage until serious repairs are required) for this engine is between 310 000 and 520 000 kilometres. Note that engine life can be longer or shorter depending on maintenance.
More engine specs
The early versions of these engines are known for their reliability and rare failures, which made them popular.
However, ...
This Volvo S80 2.4 engine oil type is 0W-30 and oil capacity is 5.7 litres.
Volvo S80 2006 D5 AWD has all four wheel drive (AWD, 4x4) and manual gearbox with 6 gears.
Volvo S80 2006 D5 AWD accelerates to speed 100 kilometres per hour in 8.9 seconds. The maximum speed of this car is 220 km/h.
In combined cycle (city and motorway), the Volvo S80 2006 D5 AWD fuel consumption is 6.9 litres per 100km (14.5 km/l), city fuel economy - 9 l/100km, fuel consumption on highway - 5.6 l/100km. Fuel tank capacity is 70 litres or 18.49 gallons, which gives a mileage up to 1000 kilometers without refueling in urban cycle and even up to 1240 kilometers on highway.
According to user reviews, the real everyday fuel consumption of this Volvo is in line with the figure specified by the manufacturer. More - Real Volvo S80 fuel consumption.
- Volvo S80 2006 2.4 D5 MT is more dynamic - it reaches 100 km/h 0.4 seconds faster (in 8.5 seconds), but manufacturer's fuel consumption is lower by 0.5 litres per 100 km or 7 % - 6.4 litres per 100 km, whereas users reported real fuel consumption is higher by 0.3 litres per 100 km or 4 % - 7.1 litres per 100 km
- Volvo S80 2006 2.4 D5 AT manufacturer's fuel consumption is higher by 0.4 litres per 100 km or 6 % - 7.3 litres per 100 km, whereas users reported real fuel consumption is higher by 1 litres per 100 km or 15 % - 7.8 litres per 100 km
- Volvo S80 2007 2.4 D5 AWD AT is more sluggish, reaching 100 km/h 0.6 seconds later (in 9.5 seconds), moreover, it is less economic with manufacturer's fuel consumption is higher by 0.9 litres per 100 km or 13 % - 7.8 litres per 100 km, whereas users reported real fuel consumption is higher by 1.1 litres per 100 km or 16 % - 7.9 litres per 100 km
Volvo S80 2006 D5 AWD technical data
| Model: | Volvo S80 D5 AWD | ||
|---|---|---|---|
| Body style: | Sedan | ||
| Production period: | 2007. May ... 2008. May | ||
| Engine: | 2400 cm3 Diesel, 5 cylinders | CO2 emissions: | 182 g/km |
| Power: | 185 HP ON 4000 RPM | Torque: | 400 NM ON 2000 RPM |
| Gearbox: | Manual gearbox (6 gears) | Drive type: | All wheel drive (AWD, 4x4) |
| Top speed: | 220 km/h | Acceleration 0-100 km/h: | 8.9 seconds |
| Fuel consumption (l/100km): | 6.9 (combined) 9.0 (urban) 5.6 (highway) | ||
| Real fuel consumption: | 6.8 l/100km (34.6 MPG) by user reviews from various sources | ||
| Fuel tank capacity: | 70 litres (18.5 gallons) | ||
| Car dimensions: | 4.85m (length) 1.86m (width) 1.49m (height) | ||
| Turning diameter: | 11 meters | ||
| Ground clearance: | 148 mm (approximate, with standard suspension, unladen vehicle) | ||
| Trunk capacity: | 480 litres | ||
| Gross weight: | 2250 kg | ||
Volvo S80 2006 D5 AWD engine D5244T4
Engine reliability and common problems:
The early versions of these engines are known for their reliability and rare failures, which made them popular.However, engine have several common weaknesses. Intake manifold swirl flaps often seize, and the plastic gears in the turbo actuator drive wear out quickly. Hydraulic lifters suffer from poor-quality oils and can start making noise as early as 100,000 km. If the alternator belt snaps, it can get caught in the timing belt, leading to catastrophic engine failure. At higher mileages, cylinder liners may crack, causing coolant to mix with oil.
A less successful engine modernization occurred in 2007 when three belts were introduced for auxiliary equipment. Two of these belts proved problematic, often causing premature roller bearing wear. This led to misalignment and, in some cases, the roller being pulled under the timing belt cover, between the timing belt and the pulley. This resulted in the timing belt jumping and pistons colliding with valves. This issue affected engines produced from 2007 to spring 2010.
Overall, this engine can last around 310,000 to 520,000 km if properly maintained, using the correct quality oil and fuel, and carrying out regular checks and maintenance.
The engine has hydraulic valve tappets (lifters), which provide quieter operation and do not require periodic adjustment, but are more complex in design and can cause serious engine damage in the event of failure.
| Engine displacement | 2400 cm3 |
|---|---|
| Number of cylinders | 5 |
| Bore (cylinder diameter) | 81 mm |
| Stroke length (piston move) | 93.15 mm |
| Compression ratio | 17.3 : 1 |
| Camshaft drive | Timing belt Timing belt engines are generally quieter and less vibrating than chain engines, but belt usually needs to be replaced more often and the risk of breakage is higher. More service info |
| Fuel system | Common Rail Common rail fuel injection provides more engine power, is quieter, more environmentally friendly and offers better fuel economy, but is more expensive to maintain and repair. |
| Volvo S80 2006 D5 AWD oil type | 0W-30 |
| Oil capacity | 5.7 litres (6 quarts) More service info |
| Power | 185 HP ON 4000 RPM |
| Torque | 400 NM ON 2000 RPM |
| Start of production (year) | 2005 |
| Duration of production | 5 years |
| Engine also used on | Volvo V70 Volvo S60 Volvo XC90 Volvo XC70 Volvo XC60 |
All Volvo S80 sedan [2006 - 2009] modifications
| Modification | Engine | Power | Consumption | Gearbox | Drive type |
|---|---|---|---|---|---|
|
Volvo S80 2007 2.0
Aug 2007 — Jan 2009 Most fuel efficient petrol version |
2.0 Petrol | 145 HP | 8.3 l/100km | Manual (5) | Front wheel |
|
Volvo S80 2007 2.0D
Apr 2007 — Jan 2009 Most fuel efficient diesel version |
2.0 Diesel | 136 HP | 5.7 l/100km | Manual (6) | Front wheel |
| Volvo S80 2006 2.4D Jun 2006 — Jan 2009 | 2.4 Diesel | 163 HP | 6.3 l/100km | Manual (6) | Front wheel |
| Volvo S80 2006 2.4D Jun 2006 — Jan 2009 | 2.4 Diesel | 163 HP | 7.2 l/100km | Automatic (6) | Front wheel |
| Volvo S80 2006 2.4 D5 Jun 2006 — Mai 2008 | 2.4 Diesel | 185 HP | 6.4 l/100km | Manual (6) | Front wheel |
| Volvo S80 2006 2.4 D5 Jun 2006 — Mai 2008 | 2.4 Diesel | 185 HP | 7.3 l/100km | Automatic (6) | Front wheel |
| Volvo S80 2007 2.4 D5 AWD Mai 2007 — Mai 2008 | 2.4 Diesel | 185 HP | 6.9 l/100km | Manual (6) | All wheel |
| Volvo S80 2007 2.4 D5 AWD Mai 2007 — Mai 2008 | 2.4 Diesel | 185 HP | 7.8 l/100km | Automatic (6) | All wheel |
|
Volvo S80 2008 2.4 D5
Nov 2008 — Jan 2009 Most powerfull diesel version (205 HP) |
2.4 Diesel | 205 HP | 6.2 l/100km | Manual (6) | Front wheel |
|
Volvo S80 2008 2.4 D5
Nov 2008 — Jan 2009 Most powerfull diesel version (205 HP) |
2.4 Diesel | 205 HP | 6.7 l/100km | Automatic (6) | Front wheel |
|
Volvo S80 2006 2.5T
Jun 2006 — Jan 2009 Most fuel efficient petrol version by real consumption |
2.5 Petrol | 200 HP | 9.3 l/100km | Manual (6) | Front wheel |
| Volvo S80 2006 2.5T Jun 2006 — Jan 2009 | 2.5 Petrol | 200 HP | 10.0 l/100km | Automatic (6) | Front wheel |
| Volvo S80 2007 3.0 T6 AWD Mai 2007 — Jan 2009 | 3.0 Petrol | 285 HP | 11.2 l/100km | Automatic (6) | All wheel |
| Volvo S80 2006 3.2 Jun 2006 — Jan 2009 | 3.2 Petrol | 238 HP | 10.0 l/100km | Automatic (6) | Front wheel |
| Volvo S80 2007 3.2 AWD Mai 2007 — Jan 2009 | 3.2 Petrol | 238 HP | 11.0 l/100km | Automatic (6) | All wheel |
|
Volvo S80 2006 4.4 i V8
Most dynamic version - 100 km/h in 6.5 seconds |
4.4 Petrol | 315 HP | 11.9 l/100km | Automatic (6) | Front wheel |
|
Volvo S80 2006 4.4 AWD
Jun 2006 — Jan 2009 Most dynamic version - 100 km/h in 6.5 seconds |
4.4 Petrol | 315 HP | 12.0 l/100km | Automatic (6) | All wheel |
|
Volvo S80 2007 4.4 V8 AWD
Mai 2007 — Jan 2009 Most dynamic version - 100 km/h in 6.5 seconds |
4.4 Petrol | 315 HP | 11.9 l/100km | Automatic (6) | All wheel |